Archive for February, 2011

Maintenance for High Mileage Vehicles In Pella Iowa

Tuesday, February 22nd, 2011

Before the recession hit, the median age for cars in the Pella Iowa area (zip code: 50219) was over nine years. And two-thirds had over 75,000 miles. At Pella Car Care we hear reports that those numbers continue to rise.

If you have a high-mileage vehicle in the Pella area, bring it in for high-mileage maintenance:
Pella Car Care
90 Truman Road
Pella, Iowa 50219
641-628-9223

Many people in Pella are keeping their vehicles longer. The economy has influenced that, but the fact that modern SUVs are more durable and reliable means that owning a high mileage vehicle doesn’t have to be a painful experience.

Local car owners in Pella with over 100,000 miles on their vehicles often ask which service intervals they should follow. Let’s start with the special needs of the older vehicle…

The reality is that time and mileage will take its toll. The engine and transmission will have more sludge. The fuel, steering and brake systems will have gum and varnish built up. There’ll be more dirt and contaminants in the fuel tank. Corrosion and deposits in the cooling system. And seals and gaskets will start to dry out.

All of this, plus normal wear and tear, means that the engine might not be as strong as new, so it just has to work harder to get the job done.

So we need to compensate. Consider high-mileage formulations for oil changes, transmission service, etc. These special formulations contain additives that condition the seals and gaskets to prevent leaks. They also have more detergents to clean sludge and other deposits. They cost a bit more, but they’re worth it.

In general, if an auto service was recommended every 15,000 miles when the car was new, you should continue to get the service done every 15,000 miles.

Talk with your service advisor at Pella Car Care about the condition of your engine. See if he thinks you should adjust your auto service intervals for oil changes or other auto maintenance to account for the older engine working harder.

Expect the oil filter to get dirty faster. Same goes for the fuel filter. And some leaks are to be expected so you need to keep a closer eye on fluid levels.

If anything, following recommended service intervals for your SUV is more important in a higher mileage vehicle. Skipping oil changes or other services can lead to problems much more quickly than with a newer vehicle.

So, have your service advisor at Pella Car Care help you with an assessment of your older car or truck. If you haven’t gotten around to a fuel system cleaning, or replacing power steering or brake fluid, a differential service or transmission service – it’s time to start taking care of those things. It’ll help keep you on the road for many more happy miles.

Share

Posted in Maintenance | No Comments »

Direct Fuel Injection Update From Pella Car Care

Thursday, February 17th, 2011

For those of you who pay attention to these things, you may have been hearing about the new direct injection engines and want to learn more about them. Some deliver the power of a V8 with the economy of a V6.

For example, in one family of engines the conventional V6 makes about 250 horsepower. The direct injection version of the same engine makes over 300 horsepower and gets essentially the same gas mileage. The turbocharged version makes over 350 horsepower.

So what are the differences from a conventional engine?

The core difference is in the fuel injection system. The system most vehicles use now is called a port injection system. The fuel injector squirts fuel into a port just outside the cylinder where it’s then drawn into the engine with the air.

With a direct injection system, the injector squirts the fuel directly into the cylinder. The gain in power and economy come because fuel injected directly into the cylinder during the combustion cycle is burned much more efficiently.

First, the fuel is squirted in at hundreds of times more pressure, so it’s atomized much better and burns cleaner and stronger. The other big advance is in electronics. Faster engine management computers can control the additional precision required to manage direct fuel injection.

Fuel injectors are precision instruments. They have to deliver a precise amount of fuel at exactly the right time. The design of the engine also dictates a particular spray pattern for the fuel. If a fuel injector is dirty or gummed up, it can’t do its job as well. That means less power and worse fuel economy for your SUV and can lead to damaged fuel injectors.

Replacing fuel injectors isn’t cheap. Direct injection injectors are even more expensive because of the extremely high-pressure they use. Same thing for diesel fuel injectors; we’re talking mortgage payment-range to replace a set of diesel injectors.

A professional fuel system cleaning from Pella Car Care gets out the gum and varnish in the whole system, including the fuel injectors. Keep those injectors clean and they’ll last a long, long time.

Share

Posted in Fuel System | No Comments »

Is Your Pella Driving Severe?

Thursday, February 10th, 2011

People near Pella Iowa often ask Pella Car Care how often they should have a particular service done. It’s a great thing to ask. You can look at your owner’s manual, or have your service advisor at Pella Car Care look up your vehicle in a service database. What you find is often a surprise to people – there are actually two service schedules.

One is the regular schedule and the other is the severe service schedule. Service intervals are shorter on the severe service schedule. When asked, most folks in Pella Iowa will say that their driving is normal and that the ‘regular’ schedule probably applies to them. ‘Severe service’ sounds pretty extreme – ‘I don’t drive like that’.

Well, here is what the manufacturers say constitutes severe driving conditions; you can draw your own conclusions.

  • Most of your trips are less than four miles.
  • Most of your trips are less than ten miles and outside temperatures are below freezing.
  • The engine is at low speed most of the time – not on the highway. You operate your vehicle in dusty areas.
  • You regularly tow a trailer or carry heavy loads.
  • Drive with a car-top carrier.
  • Stop and go driving.
  • Driving in very hot or very cold weather.

If that’s severe driving, what constitutes regular driving? Well, it would look something like this: I live somewhere with moderate temperatures all year round – I’m thinking San Diego here. And I live close to a freeway on-ramp. Everywhere I need to go is right off the freeway, at least four miles from my home. I can drive at a steady 60 miles per hour when I’m on the freeway.

I don’t know about you, but that doesn’t sound like my normal driving. It sounds more like ideal conditions. I live where it gets hot in the summer and cold in the winter. I run short errands around Pella. Occasionally we load up for family trips.

For me, normal driving includes elements of severe service driving. So here’s what I tell people: think about how you drive, where you live, where you go and what you are expecting to with your vehicle in the near future.

Picture a line with ‘regular’ on one end and ‘severe’ on the other, and make a judgment on where you fall. If your regular oil change recommendation is 5,000 miles and the severe service recommendation is 3,000 – when should you change your oil? For me, it’s closer to 3,000 miles. For my wife, it’s closer to 5,000 miles. Your auto service advisor at Pella Car Care will be happy to have this discussion with you and help you sort it out.

Just a quick word on why severe service intervals are shorter. One has to do with heat. That can either be external heat from the weather or engine and transmission heat from stop and go driving or working extra hard moving heavy loads or towing. The heat causes the fluids like oil and transmission fluid to break down more quickly and then they aren’t as effective.

Another factor is water. Moisture naturally collects in fluids as they cool. In your motor oil, for example, if you don’t drive long enough for the oil to fully heat up, the water won’t evaporate. Water in the oil can lead to the buildup of damaging sludge.

If you live where the air is dusty or polluted, fluids will become contaminated and filters will get dirtier more quickly.

So make an honest evaluation of your driving conditions. You’ve made the commitment to take care of your vehicles, so it only makes sense to follow the right schedule.

Share

Posted in Service Intervals | No Comments »

Fuel Filter Service in Pella Iowa

Thursday, February 3rd, 2011

There are a surprising number of small, inexpensive parts that can lead to expensive engine damage when they fail. It doesn’t seem right.

Fortunately a lot of those things can be taken care of in routine maintenance. They may not be easy to remember, because it is a long list, but your service center at Pella Car Care can help you know what’s scheduled to be taken care of.

Some of us really don’t look forward to going in for an oil change and then getting a list of the other things the manufacturer recommends.

But automotive maintenance is all about prevention, and addressing small problems before they get big. Let’s take the fuel filter for example.

You may not know this but the median age for private vehicles on our Iowa roads is over nine years. When cars get older, five years or so, they’ve accumulated a lot of dirt and rust in their gas tanks. If that dirt gets into the engine it can cause thousands of dollars worth of damage. So somewhere between that dirty gas tank and the price of a great vacation – is the lowly fuel filter: a very inexpensive part that doesn’t cost too much to replace. And your car’ll just run better too.

A clogged fuel filter can’t let enough fuel through. You might notice at first that your car is running fine around town, but struggles or sputters on the Pella Iowa freeway or when you accelerate. Enough fuel can’t get through to meet the demands of higher speed. If it gets bad enough your engine might just shut off or not start at all, which could be dangerous.

Some fuel filters have a bypass. When they get clogged, they allow dirty fuel to move around the filter element so dirt ends up in the engine. We’ve already talked about how expensive that can be.

The fuel filter is even very important for newer cars. The fuel is still dirty even if there isn’t rust in the tank. It’s just that the fuel filter will need to be changed more frequently as the vehicle gets older.

How often should you change your fuel filter? Check your owner’s manual. Your service advisor at Pella Car Care can tell you as well. It’s usually around thirty thousand miles or so. Ask if it’s time for a full fuel system cleaning as well. They often go hand in hand.

It’s good to know that your service center has your back. When you’re motivated to maintain your vehicle’s performance and to reduce operating costs, you’ll think of Pella Car Care as your ally – and maybe even your memory.

Share

Posted in Fuel System | No Comments »